Frequent question: Can you ride a motorcycle with a bad stator?

How do I know if my stator is bad?

Insert each probe into a stator socket. You should read around 0.2 to 0.5 ohms. If you show an open circuit with the “Open” or infinity reading or have higher resistance, then the stator is bad and you must replace it. If these tests all produce positive results, then the stator itself is good.

How much does it cost to fix a stator?

Stator & Rotor

A new stator and rotor set typically costs between $250 and $1,500. They are stationary and rotating parts of any system that generates electricity. When they stop working seamlessly, they need repair or replacement.

What can cause a motorcycle stator to go bad?

To answer why stators fail, it is because the coating on the windings breaks down, usually because of heat, causing a short which can also burn the fine wire of the winding in two at the short causing an open circuit. The way to prevent failures is to prevent the heat.

What happens when a stator fails?

The stator coil generates the power for the spark plug and other accessories on small engines Without a stator there would be no spark at all, meaning the engine won’t run. While a stator is dying, it can produce a weak spark, causing the engine to miss or run poorly.

THIS IS IMPORTANT:  Is it legal to write up an employee?

Will a bad stator drain a battery?

Will a bad stator drain a battery? As far as the battery, yes a bad stator/regulator can destroy a new battery. If it’s run at a very low voltage without being recharged then it can be destroyed. … In most cases if we replace a stator or regulator the battery has to be changed as well as it won’t hold a charge.

How do I know if my stator or rectifier is bad?

Key Signs to Look For

You won’t have any trouble diagnosing the faulty regulator rectifier if the battery is the cause. You’ll note signs right away like poor starts, fluctuating meter readings, and dimmed headlights. around 13 volts, the bike will start to drain the battery.

Do you have to drain oil to change stator?

No, you shouldn’t need to even on a side stand. You might get a little oil out, but not a lot.

How hard is it to replace a stator?

Replacing the stator is not too complicated and requires a socket set and some heat resistant gasket repair silicone only. … On 2006-07 Honda Fireblades the stator is located on the left hand side behind the crash protector.

How long does it take to change a stator and rectifier?

Work time is probably around an hour or two, two if they relocated the regulator and with hourly rounding, so I’d say they overcharged you by about $100-150.