How long does Harley stator last?

What are the symptoms of a bad stator on a Harley Davidson?

The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring). Hard starts and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.

How do I know if my motorcycle stator is bad?

The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring). Hard starts and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.

Will a Harley run with a bad stator?

The stator system charges your battery and replenishes it. You could actually run your motorcycle just fine for some time without a working stator as the battery has reserve current. Of course, the battery would eventually die.

What causes a motorcycle stator to go bad?

To answer why stators fail, it is because the coating on the windings breaks down, usually because of heat, causing a short which can also burn the fine wire of the winding in two at the short causing an open circuit. The way to prevent failures is to prevent the heat.

THIS IS IMPORTANT:  What transformation does not change the orientation of a figure?

Will a bad stator drain a battery?

Will a bad stator drain a battery? As far as the battery, yes a bad stator/regulator can destroy a new battery. If it’s run at a very low voltage without being recharged then it can be destroyed. … In most cases if we replace a stator or regulator the battery has to be changed as well as it won’t hold a charge.

What problems can a bad stator cause?

Runs bad at lower rpms but runs good at higher rpms (Low speed coil going bad) Runs good at lower rpms but runs bad at higher rpms (High speed coil is going bad) Backfiring and just won’t run good. Sled slowly loses power during the course of the day.

Can you ride a motorcycle with a bad stator?

If the stator is bad, the bike won’t run at all. The stator generates energy for spark. Assuming the air cleaner is clean and other general maintenance has been performed, if the bike won’t kick start but runs as you state, the problem is probably either the spark plug and/or fuel delivery.

How do I know if my stator is bad?

Insert each probe into a stator socket. You should read around 0.2 to 0.5 ohms. If you show an open circuit with the “Open” or infinity reading or have higher resistance, then the stator is bad and you must replace it. If these tests all produce positive results, then the stator itself is good.

How long does it take to change a stator?

A good tech can change a stator in 3 hours and a belt in 6 or 7 hours. Your belt should go over 100,000 if it has been properly maintained.

THIS IS IMPORTANT:  Does a tune up make your car faster?

Can a stator be rebuilt?

All rebuilt stators require a core exchange and come with a one year replacement warranty. Most new and rebuilt stators are built to stock specification, but we do offer some high output stator versions as part of the Hot Shot Series so you can get even more electrical power from your machine.